Two-Stage Evaporative Cooler for Mushroom-Growing Houses in Hot and Humid Climates

Document Type : Original Research

Author
C. Chantana
Department of Mechanical Engineering, Faculty of Engineering at Kamphaeng Saen, Kasetsart University, Kamphaeng Saen Campus, Nakhon Pathom 73140, Thailand.
10.52547/jast.25.2.457
Abstract
Shiitake (Lentinula edodes) is one of the most cultivated mushrooms in the world, and it prefers a temperate climate. The improvement of warm-weather shiitake strains is one way to increase shiitake yield in Thailand. Mushroom-growing houses should be equipped with mechanical cooling to control and establish the optimal environment for cultivation. In this study, an Indirect–Direct Evaporative Cooling (IDEC) system consisting of a cooling coil and evaporative cooling (cellulose pad) was tested for its suitability for shiitake cultivation from August 2020 to December 2020. Under optimal shading of, and growing conditions, the IDEC system maintained the air temperature (27–28°C) and relative humidity in the required ranges. The mushroom compost was almost completely brown after the 100-day test and ready for the next fruiting phase. When compared with the fan-pad system, regression analysis showed that the two systems exhibited similar performance and had similar equipment costs. However, the IDEC system had a lower air temperature at a lower relative humidity, and its efficiency was over 100%. This study demonstrated that the IDEC system can be applied to promote shiitake cultivation in hot and humid climates.

Keywords

Subjects

1. Krishan, K. 2015. Role of edible mushrooms as functional foods-A review. South Asian J. of Food Technology and Environment 211-218.
2. Aji, I. 2009. Development and Production of Lentinula edodes (Shiitake mushrooms) on Inoculated Logs of a Range of Tree Species. Thesis. University of Melbourne.
3. Wasser, S.P. 2005. Shiitake (Lentinus edodes). Encyclopedia of Dietary supplements. 653:644. Marcel Dekker: New York.
4. Debajit, M., and G. Sudip. 2018. Evaporative cooling technologies for greenhouses: A comprehensive review. AgriculturistsEngInt: CIGR Journal 20(1):1-15.
5. Ganguly, A., and S. Ghosh. 2007. Modeling and analysis of a fan-pad ventilated floricultural greenhouse. Energy and Buildings 39(10):1092-1097.
6. Kittas, C., T. Bartzanas, and A. Jaffrin. 2003. Temperature Gradients in a Partially Shaded Large Greenhouse equipped with Evaporative Cooling Pads. Biosystems Engineering 85(1):87-94.
7. Sethi, V.P., and S.K. Sharma. 2007. Experimental and economic study of a greenhouse thermal control system using aquifer water. Energy Conversion and Management 48(1):306-319.
8. López, A., D.L. Valera, F.D. Molina-Aiz, and A. Peña. 2012. Sonic anemometry to evaluate airflow characteristics and temperature distribution in empty Mediterranean greenhouses equipped with pad-fan and fog systems. Biosystems Engineering 113(4):334-350.
9. Thepa, S., K. Kirtikara, J. Hirunlabh, and J. Khedari. 1999. Improving indoor conditions of a Thai-style mushroom house by means of an evaporative cooler and continuous ventilation. Renewable Energy 17(3):359-369.
10. William, J.D., and C.H. Sam 2009. Two-stage evaporative cooling systems in hot and humid climate. Proc. of the Tianjin-Hong Kong Joint Symposium 64-76.
11. Camargo, J.R., C.D. Ebinuma, and S. Cardoso. 2006. Three methods to evaluate the use of evaporative cooling for human thermal comfort. Revista de Engenharia Térmica 5(2):9-15.
12. Chantana, C. 2019. A Cooling system for a mushroom house for use in the upper central region climate of Thailand. Science and Technology. Naresuan University J 27(3):10-19.
13. Miyazaki, T. 2018. Evaporative heat exchangers. Handbook of thermal science and engineering. Springer: Cham. doi: 10.1007/978-3-319-26695-422.
14. Stull, R. 2011. Wet-bulb temperature from relative humidity and air temperature. Journal of Applied Meteorology and Climatology 50(11):2267-2269. doi: 10.1175/JAMC-D-11-0143.1.
15. Taylor, J.R. 1982. An Introduction to error analysis. University Science Books. 2nd ed., 41, 75. California.
16. Stamets, P., and J.S. Chilton 1983. The Mushroom Cultivator: A practical guide to a growing mushrooms at home. Agarikon Press: Washington.
17. Obando, F.A., A.P. Montoya, J.A. Osorio, F.A. Damasceno, and T. Norton. 2020. Evaporative pad cooling model validation in a closed dairy cattle building. Biosystems Engineering 198:147-162.
18. Ahmed, H.A., Y. Tong, Q. Yang, A.A. Al-Faraj, and A.M. Abdel-Ghany. 2019. Spatial distribution of air temperature and relative humidity in the greenhouse as affected by external shading in arid climates. Journal of Integrative Agriculture 18(12):2869-2882.
19. Abbouada, S.K., and E.A. Almuhanna. 2012. Improvement of evaporative cooling system efficiency in greenhouses. Int. J Latest Trends Agr. Food Science 2(2):83-89.
20. Kenneth, N.B., and C. Patrick 2010. Data analysis with Microsoft Excel. Brooks/Cole: Boston, USA, 318-344.
21. Hanchaiyungwa, N. 2003. Feasibility study and energy consumption of evaporative cooling for lentinun edodes (Berk.) Sing house. Masters thesis. King Mongkut’s University of Technology Thonburi. (Thai language).
22. Rattanathanaopat, N. 2003. Improving in efficiency of evaporative cooling on pouetry. Masters thesis. King Mongkut’s University of Technology Thonburi. (Thai language).
23. Andre-Ledoux, N., N.P. Idriss, S. Christopher, and T.G. Noumbo. 2020. Cultivation of Lentinus squarrosulus Mont. and Lentinus sajor-caju Fr. on agroforestry wastes under field conditions. Int. J. of Agricultural Sciences and Veterinary Medicine 8(2):20-25.
24. Alklaibi, A.M. 2015. Experimental and theoretical investigation of internal two-stage evaporative cooler. Energy Conversion and Management 95: 140-148.
25. Kiyaninia, A., H. Karimi, and V.M. Madadi Avargani. 2019. Exergoeconomic analysis of a solar photovoltaic-based direct evaporative air-cooling system. Solar Energy 193:253-266.
Journal of Agricultural Science and Technology
Volume 25, Issue 2
January and February 2023
Pages 457-468