Pomegranate (Punica granatum L.) Fruit Storability Improvement Using Pre-storage Chitosan Coating Technique

Authors
Z. Zamani 1
F. Varasteh 2, 3
K. Arzani 4
M. Barzegar 5
1 Department of Horticultural Science, University of Tehran, Karaj, Islamic Republic of Iran.
2 Department of Horticultural Science, Faculty of Agriculture, Tarbiat Modares University (TMU), Tehran, Iran.
3 Department of Horticultural Science, Gorgan University of Agricultural Sciences and Natural Resources, Gorgan, Islamic Republic of Iran.
4 Department of Horticultural Science, Faculty of Agriculture, Tarbiat Modares University, Tehran, Islamic Republic of Iran.
5 Department of Food Science and Technology, Faculty of Agriculture, Tarbiat Modares University, Tehran, Islamic Republic of Iran.
Abstract
Application of edible coatings to enhance storage life of fresh fruit has recently been under considerable attention. This experiment was conducted in order to explore the effect of chitosan coating and storage temperature on the postharvest life of pomegranate (Punica granatum L.) fruit. Therefore, pomegranate fruits ‘Rabbab-e-Neyriz’ were dipped in 0, 1 and 2% aqueous chitosan solutions, air dried and then stored at 2 and 5˚C with 90% relative humidity for up to 135 days. The application of chitosan coating retarded the respiration rate and weight loss of the fruit regardless of temperature during storage period; however, the retention was higher at 2 than 5˚C. After 135 days of storage, the highest (18.19%) and lowest (9.33%) weight losses were recorded in the control fruit stored at 5˚C and 2% chitosan-treated fruit stored at 2˚C, respectively. The results revealed that postharvest weight losses in pomegranate fruit mainly related to weight losses in the fruit peel and 4-8% reduction in peel weight percentage (of whole fruit) was recorded in the treated fruit. A slight decline in Soluble Solids Content (SSC) and Titratable Acidity (TA) was found during storage in all treatments, while pH and maturity index increased slowly. Scanning electron microscopy of the treated fruit demonstrated that chitosan covered whole pericarp surface and pores of the coated fruit, and revealed more shrivelling symptoms on the peel of the non-coated fruit during storage.

Keywords

1. Abbasi, N. A., Iqbal, Z., Maqbool, M. and Hafiz, I. A. 2009. Postharvest Quality of Mango (Mangifera indica L.) Fruit as Affected by Chitosan Coating. Pak. J. Bot., 41: 343-357.
2. Ahlawat, A., Saha, A., Tyagi, Y. K. and Gupta, R. K. 2015. Development of Chitosan Based Edible Coatings to Study Sapota (Manilkara zapota) Fruit Shelf Life. J. Chem. Pharma. Res., 7(1): 879-885.
3. Alighourchi, H., Barzegar, M. and Abbasi, S. 2008. Anthocyanins Characterization of 15 Iranian Pomegranate (Punica granatum L.) Varieties and Their Variation after Cold Storage and Pasteurization. Eur. Food Res. Technol., 227: 881-887.
4. Artes, F., Gines Marin, J. and Martinez, J. A. 1996. Controlled Atmosphere Storage of Pomegranate. Z. Lebensm. Unters. Forch., 203: 33-37.
5. Artes, F. and Tomas-Barberan, F. A. 2000. Postharvest Technological Treatments of Pomegranate and Preparation of Derived Products. CIHEAM-Options Mediterr., 42: 199-204.
6. Artes, F., Villaescusa, R. and Tudela, J. A. 2000. Modified Atmosphere Packaging of Pomegranates. J. Food Sci., 65: 1112-1116.
7. Arzani, K., Nejatian, M. A. and Karimzadeh, G. 2005. Apricot (Prunus armeniaca) Pollen Morphological Characterization through Scanning Electron Microscopy, Using Multivariate Analysis. New Zeal. J. Crop Hort., 33: 381-388.
8. Arzani, K., Khoshghalb, H., Malakouti, M. J. and Barzegar, M. 2011. Total Oxalate Soluble Pectin Concentration in Asian Pear (Pyrus serotina Rehd) Fruit in Relation to Ripening, Storage and Internal Browning Disorder. J. Agr. Sci. Tech., 13: 611-626.
9. Bal, E. 2013. Postharvest Application of Chitosan and Low Temperature Storage Affect Respiration Rate and Quality of Plum Fruit. J. Agr. Sci. Tech., 15: 1219-1230.
10. Baldwin, E. A, Nisperos-Carriedo, M. O. and Baker, R. A. 1995. Use of Edible Coatings to Preserve Quality of Lightly (and Slightly) Processed Products. Crit. Rev. Food Sci. Nutr., 35: 509-524.
11. Bautista-Banos, S., Hernandez-Lauzardo, A. N., Velazquez-del Valle, M. G., Hernandez-Lopez, M., AitBarka, E., Bosquez-Molina, E. and Wilson, C. L. 2006. Chitosan as a Potential Natural Compound to Control Pre and Postharvest Diseases of Horticultural Commodities. Crop Prot., 25: 108-118.
12. Ben-Arie, R., Segal, N. and Guelfat-Reich, S. 1984. The Maturation and Ripening of the 'Wonderful’ Pomegranate. J. Am. Soc. Hortic. Sci., 109: 898-902.
13. Chien, P. J., Sheu, F. and Lin, H. R. 2007. Coating Citrus (Murcott tangor) Fruit with Low Molecular Weight Chitosan Increases Postharvest Quality and Shelf Life. Food Chem., 100: 1160-1164.
14. Du, J., Gemma, H. and Iwahori, S. 1997. Effects of Chitosan Coating on the Storage of Peach, Japanese Pear and Kiwifruit. J. Jpn. Soc. Hortic. Sci., 66: 15–22.
15. Du, J., Gemma, H. and Iwahori, S. 1998. Effects of Chitosan Coating on the Storability and on the Ultrastructural Changes of 'Jonagold’ Apple Fruit in Storage. Food Preserv. Sci., 24: 23-29.
16. El Ghaouth, A., Arul, J., Ponnampalam, R., Castaigne, F. and Arul, J. 1992. Chitosan Coating to Extend the Storage Life of Tomatoes. Hort. Sci., 27: 1016-1018.
17. El Ghaouth, A., Arul, J. and Ponnampalam, R. 1991a. Use of Chitosan Coating to Reduce Water Loss and Maintain Quality of Cucumbers and Bell Pepper Fruits. J. Food Process. Preserv., 15: 359-368.
18. El Ghaouth, A., Ponnampalam, R. and Boulet, M. 1991b. Chitosan Coating Effect on Storability and Quality of Fresh Strawberries. J. Food Sci., 56: 1618-1621.
19. Elyatem, S. M. and Kader, A. A. 1984. Postharvest Physiology and Storage Behaviour of Pomegranate Fruits. Sci. Hortic., 24: 287-298.
20. Eris, A. and Turk, R. 2000. Heat Treatments and Different Packaging Materials for the Modified Atmosphere Storage of Pomegranate Fruits. CIHEAM-Options Mediterr., 42: 185-193.
21. Ghasemnezhad, M., Zareh, S., Rassa, M. and Sajedi, R. H. 2013. Effect of Chitosan Coating on Maintenance of Aril Quality, Microbial Population and PPO Activity of Pomegranate (Punica granatum L. cv. Tarom) at Cold Storage Temperature. J. Sci. Food Agric., 93: 368-374.
22. Ghasemnezhad, M., Shiri, M.A. and Sanavi, M. 2010. Effect of Chitosan Coatings on Some Quality Indices of Apricot (Prunus armeniaca L.) during Cold Storage. Caspian J. Env. Sci., 8(1): 25-33.
23. Gil, M. I., Sanchez, R., Ginesmarin, J. and Francisco, A. 1996. Quality Changes in Pomegranates during Ripening and Cold Storage. Eur. Food Res. Technol., 202: 481-485.
24. Gross, K. C., Wang, C. Y. and Saltveit, M. 2016. The Commercial Storage of Fruits, Vegetables, and Florist and Nursery Stocks. Agriculture Handbook Number 66, Agricultural Research Service, United States Department of Agriculture, 780 p.
25. Hess-Pierce, B. and Kader, A. A. 2003. Responses of Pomegranates to Controlled Atmospheres. Acta Hort., 600: 751-757.
26. Jafari, A., Arzani, K., Fallahi, E. and Barzegar, M. 2014. Optimizing Fruit Yield, Size, and Quality Attributes in ‘Malase Torshe Saveh’ Pomegranate through Hand Thinning. J. Am. Pomol. Soc., 68(2): 89-96.
27. Jiang, Y. and Li, Y. 2001. Effects of Chitosan Coating on Postharvest Life and Quality of Longan Fruit. Food Chem., 73: 139–143.
28. Jiang, Y., Li, Y. and Jiang, W. 2005. Effects of Chitosan Coating on Shelf Life of Cold-stored Litchi Fruit at Ambient Temperature. LWT, 38: 757-761.
29. Jianglian, D. and Shaoying, Z. 2013. Application of Chitosan Based Coating in Fruit and Vegetable Preservation: A Review. J. Food Process. Technol., 4: 5.
30. Kader, A. A., Chordas, A. and Elyatem, S. M. 1984. Responses of Pomegranates to Ethylene Treatment and Storage Temperature. Calif. Agric., 38(748):14-15.
31. Kaya, M., Cesoniene, L., Daubaras, R., Leskauskaite, D. and Zabulione, D. 2016. Chitosan Coating of Red Kiwifruit (Actinidia melanandra) for Extending of the Shelf Life. Int. J. Biol. Macromol., 85: 355-360.
32. Li, H. and Yu, T. 2000. Effect of Chitosan on Incidence of Brown Rot, Quality and Physiological Attributes of Postharvest Peach Fruit. J. Sci. Food Agric., 81: 269-274.
33. Lin, L., Wang, B., Wang, M., Cao, J., Zhang, J., Wu, Y. and Jiang, W. 2008. Effects of a Chitosan-based Coating with Ascorbic Acid on Post-harvest Quality and Core Browning of Yali Pears (Pyrus bertschneideri Rehd.). J. Sci. Food Agric., 88: 877-884.
34. Mirdehghan, S. H., Rahemi, M., Castillo, S., Martianez-Romero, D., Serrano, M. and Valerro, D. 2007. Prestorage Application of Polyamines by Pressure or Immersion Improves Shelf Life of Pomegranate Stored at Chilling Temperature by Increasing Endogenous Polyamine Levels. Postharvest Biol. Technol., 44: 26-33.
35. Nanda, S., Sudhakar Rao, D. V. and Krishnamurthy, S. 2001. Effects of Shrink Film Wrapping and Storage Temperature on the Shelf Life and Quality of Pomegranate Fruits cv. Ganesh. Postharvest Biol. Technol., 22: 61-69.
36. Poyrazoglu, E., Gokmen, V. and Artik, N. 2002. Organic Acids and Phenolic Compounds in Pomegranates (Punica granatum L.) Grown in Turkey. J. Food Compos. Anal., 15: 567-575.
37. Shahidi, F., Arachchi, J. K. V. and Jeon, Y. J. 1999. Food Applications of Chitin and Chitosans. Trends Food Sci. Technol., 10: 37-51.
38. Shiekh, R. A., Malik, M. A., Al-Thabaiti, S. A. and Shiekh, M. A. 2013. Chitosan as a Novel Edible Coating for Fresh Fruits. Food Sci. Technol. Res., 19(2): 139-155.
39. Varasteh, F. and Arzani, K. 2009. Classification of Some Iranian Pomegranate (Punica granatum L.) Cultivars by Pollen Morphology Using Scanining Electron Microscopy. Hort. Environ. Biotechnol., 50: 24-30.
40. Varasteh, F., Arzani, K., Zamani, Z. and Mohseni, A. 2009. Evaluation of the Most Important Fruit Characteristics of Some Commercial Pomegranate (Punica granatum L.) Cultivars of Iran. Acta Hort., 818: 103-108.
41. Varasteh, F., Arzani, K., Barzegar, M. and Zamani, Z. 2012. Changes in Anthocyanins in Arils of Chitosan-coated Pomegranate (Punica granatum L. cv. Rabbab-e-Neyriz) Fruit during Cold Storage. Food Chem., 130: 267-272.
Journal of Agricultural Science and Technology
Volume 19, Issue 2
March and April 2017
Pages 389-400