Optimization of Different Drying Systems for Lavender Leaves Applying Response Surface Methodology

Document Type : Original Research

Authors
H. Homayounfar 1
R. Amiri Chayjan 1
H. Sarikhani 2
R. Kalvandi 3
1 Department of Biosystems Engineering, Faculty of Agriculture, Bu-Ali Sina University, Hamedan 65178-38695, Islamic Republic of Iran.
2 Department of Horticultural Sciences, Faculty of Agriculture, Bu-Ali Sina University, Hamedan 65178-38695, Islamic Republic of Iran.
3 Department of Natural Resources, Research and Education Center for Agricultural and Natural Resources, Hamedan, Islamic Republic of Iran.
Abstract
Lavender leaves, widely used as flavors for foods and beverages, are a rich source of phenol components and antioxidant. Drying method is of vital importance for keeping these compounds. In this study, lavender leaves were dried by means of Atmospheric Freeze (AF), Multi-Stage Semi-Industrial Continuous (MSSIC), and Near Infrared-Vacuum (NIR-Vacuum) dryers and optimized by Response Surface Methodology (RSM) for the highest drying rate, total phenol content, antioxidant capacity, and the lowest color indicators change. Lavender leaves were also dried under natural conditions as the traditional method. Multi-stage drying caused tempering phenomenon and, consequently, drying rate increased obviously. Near infrared-vacuum dryer had suitable performance on keeping the active ingredients of lavender leaves. Optimum point to dry lavender leaves in atmospheric freeze dryer was found to be -5℃. The optimum temperature points in the multi-stage semi-industrial continuous dryer were achieved to be 60, 40, and 60℃ for the first, second, and third stages, respectively. The optimum point in near infrared-vacuum dryer was 60℃ and 20 kPa for air temperature and pressure, respectively. Based on the results, among several drying methods, near infrared-vacuum dryer was the more suitable for drying lavender leaves.

Keywords

Subjects

Alaei, B. and Chayjan, R.A. 2015. Modelling of nectarine drying under near infrared - vacuum conditions. Acta Scient. Polono. Technol. Alimen., 14(1): 15-27.
Altay, K., Hayaloglu, A.A., Dirim, S.N. 2019. Determination of the drying kinetics and energy efficiency of purple basil (Ocimum basilicum L.) leaves using different drying methods. Heat Mass Trans., 1-12.
Argyropoulos, D. and Müller, J. 2014. Changes of essential oil content and composition during convective drying of lemon balm (Melissa officinalis L.). Indust. Crops Prod.,52: 118-124.
Beigi, M., 2019. Drying of mint leaves: influence of the process temperature on dehydration parameters, quality attributes, and energy consumption. J. Agric. Sci. Technol., 21: 77-88.
Borah, A., Sethi, L.N., Sarkar, S. and Hazarika, K. 2017. Drying kinetics of sliced turmeric (Curcuma longa L.) in a solar-biomass integrated drying system. J. Food Process. Preserv., 41(3): e12904.
Brand-Williams, W., Cuvelier, M.E. and Berset, C. 1995. Use of a free radical method to evaluate antioxidant activity. LWT - Food Sci. Technol., 28(1): 25-30.
Chayjan, R.A. and Kaveh, M. 2016. Drying characteristics of eggplant (Solanum melongena L.) slices under microwave-convective drying. Res. Agric. Eng., 62(4): 170-178.
Claussen, I.C., Ustad, T.S., Strmmen, I. and Walde, P.M. 2007. Atmospheric freeze drying—a review. Drying Technol., 25(6): 947-957.
Colucci, D., Fissore, D., Mulet, A. and Cárcel, J.A. 2017. On the investigation into the kinetics of the ultrasound-assisted atmospheric freeze drying of eggplant. Drying Technol.,35:1-14.
Da Porto, C., Decorti, D. and Kikic, I. 2009. Flavour compounds of Lavandula angustifolia L. to use in food manufacturing: Comparison of three different extraction methods. Food Chem., 112(4): 1072-1078.
Dev, S.R. and Raghavan, V.G. 2012. Advancements in drying techniques for food, fiber, and fuel. Drying Technol.,30(11-12): 1147-1159.
Dwivedy, S., Rayaguru, K., and Sahoo, G. 2012. Effect of drying methods on quality characteristics of medicinal indian borage (Coleus Aromaticus) leaves. J. Food Process. Technol., 3(188): 2.
Fealekari, M. and Chayjan, R.A. 2014. Optimization of convective drying process for Persian shallot using response surface method (RSM). Agric. Eng. Inter.: CIGR J., 16(2): 157-166.
Fissore, D., Pisano, R. and Barresi, A.A. 2014. Applying quality-by-design to develop a coffee freeze-drying process. J. Food Eng., 123: 179-187.
Hassanain, A. 2011. Drying sage (Salvia officinalis L.) in passive solar dryers. Res. Agric. Eng., 50(1): 19-29.
Harborne, J.B. and Williams, C.A. 2002. Phytochemistry of the genus Lavandula. Medicin. arom. plants–indust. profiles, CRC Press, USA.
Jangam, S.L., Law, C.L. and Mujumdar, A.S. 2011. Drying of Foods Vegetables and Fruits. Vol. 2. Pp. 220. Available online at: https://www.arunmujumdar.com/file/Publications/books/Drying%20of%20FVF_Volume%202.pdf (accesed: 18/12/2018)
Jha, S. N. 2010. Nondestructive Evaluation of Food Quality. Springer pp. 288.
Krempski-Smejda, M., Stawczyk, J., Śmigielski, K. and Prusinowska, R. 2015. Drying of herbal product in closed system. Drying Technol., 33(13): 1671-1677.
Lima-Corrêa, R.D.A.B., Andrade, M.S., Da Silva, M.F.d.G.F., Freire, J.T. and Ferreira, M.d.C. 2017. Thin-layer and vibro-fluidized drying of basil leaves (Ocimum basilicum L.): analysis of drying homogeneity and influence of drying conditions on the composition of essential oil and leaf colour. J. Applied Res. Medicin. Arom. Plants, 7: 54-63.
Lis-Balchin, M.T. 2012. Lavender, in: Handbook of Herbs and Spices, K.V. Peter, Editor. Woodhead Publishing. p. 329-347.
Oniszczuk, A., Podgórski, R., Oniszczuk, T., Żukiewicz-Sobczak, W., Nowak, R., and Waksmundzka-Hajnos, M. 2014.Extraction methods for the determination of phenolic compounds from Equisetum arvense L. herb. Industrial Crops and Products, 61, 377-381.Moses, J.A., Norton, T., Alagusundaram, K. and Tiwari, B.K. 2014. Novel drying techniques for the food industry. Food Eng. Reviews,6(3): 43-55.
Nozad, M., Khojastehpour, M., Tabasizadeh, M., Azizi, M., Miraei Ashtiani, S.H. and Salarikia, A. 2016. Characterization of hot-air drying and infrared drying of spearmint (Mentha spicata L.) leaves. J. Food Measur. Charac., 10(3): 466-473.
Rahman, S.M.A. and Mujumdar, A.S. 2008. A novel atmospheric freeze-drying system using a vibro-fluidized bed with adsorbent. Drying Technol., 26(4): 393-403.
Reyes, A., Mahn, A. and Huenulaf, P. 2011. Drying of apple slices in atmospheric and vacuum freeze dryer. Drying Technol., 29(9): 1076-1089.
Torki-Harchegani, M., Ghasemi Pirbalouti, A., Ghanbarian, D., 2018. Influence of Microwave Power on Drying Kinetic, Chemical Composition and Antioxidant Capacity of Peppermint Leaves. Journal of Essential Oil Bearing Plants.,21: 430-439.
Salarikia, A., Miraei, S., Ashtiani, H., and Golzarian, M.R. 2017. Comparison of drying characteristics and quality of peppermint leaves using different drying methods. J. Food Process. Preserv.,41(3): paper # e12930.
Shi, X.F., Chu, J.Z., Zhang, Y.F., Liu, C.Q. and Yao, X.Q. 2017. Nutritional and active ingredients of medicinal chrysanthemum flower heads affected by different drying methods. Indust. Crops Prod., 104: 45-51.
Singleton, V.L. and Rossi J.A. 1965. Colorimetry of total phenolics with phosphomolybdic-phosphotungstic acid reagents. American J. Enol.Viticul., 16(3): 144-158.
Sledz, M. and Witrowa-Rajchert, D. 2012. Influence of microwave-convective drying of chlorophyll content and colour of herbs. Acta Agrophysica., 19(4): 865-876.
Sousa, A.D., Ribeiro, P.R.V., Canuto, K.M., Zocolo, G.J., Pereira, R.C.A., Fernandes, F.A.N. and De Brito E. S. 2017. Drying kinetics and effect of air-drying temperature on chemical composition of phyllanthus amarus and phyllanthus niruri. Drying Technol., 36(5): 609-616.
Sumic, Z., Vakula, A., Tepic, A., Cakarevic, J., Vitas, J. and Pavlic, B. 2016. Modeling and optimization of red currants vacuum drying process by response surface methodology (RSM). Food Chem., 203: 465-475.
Stawczyk, J., Li, S., Witrowa-Rajchert, D. and Fabisiak, A. 2006. Kinetics of atmospheric freeze-drying of apple. Trans. Porous Media, 66(1-2): 159-172.
Uribe, E., Marin, D., Vega-Galvez, A., Quispe-Fuentes, I. and Rodriguez, A. 2016. Assessment of vacuum-dried peppermint (Mentha piperita L.) as a source of natural antioxidants. Food Chem., 190: 559-565.
Journal of Agricultural Science and Technology
Volume 22, Issue 3
March and April 2020
Pages 679-692