Drying Kinetics and Quality Characteristics of Saffron Dried with a Heat Pump Assisted Hybrid Photovoltaic-thermal Solar Dryer

Authors
H. Mortezapour
B. Ghobadian
M. H. Khoshtaghaza
S. Minaei
Department of Mechanics of Agricultural Machinery, Faculty of Agriculture, Tarbiat Modares University, Islamic Republic of Iran.
Abstract
In the present study, saffron was dried using a heat pump-assisted hybrid photovoltaic-thermal solar dryer. The effect of different drying air temperatures at three levels (40, 50, and 60oC) and two different modes of the dryer (with and without heat pump system) were investigated on drying behaviour of saffron. After collecting the pertinent data, eleven drying models were used to describe drying characteristics of saffron. Quality characteristics of the dried products (including: colouring, aromatic strength and bitterness) were also evaluated. The results indicated that drying time decreased by 62% with increasing air temperature from 40 to 60oC. Moreover, applying heat pump with the dryer reduced RH of drying air and, consequently, enhanced drying rate and shortened drying period by 40%. A two-term drying model presented a relatively higher R2 and lower, MBE, and RMSE values at both modes of drying and, therefore, was selected to explain drying behaviour of saffron among the other models. The results of saffron quality evaluation showed that colouring characteristics of saffron improved with drying temperature and heat pump system. Meanwhile, aromatic strength of saffron increased with increasing air temperature. But, no significant change in bitterness was observed at different levels of temperature and heat pump system.

Keywords

1. Agrawal, Y. C. and Singh, R. P. 1977. Thin-Layer Drying Studies on Short-grain Rice. ASAE Paper, No. 77-3531.
2. Aktaş, M., Ceylan, İ. and Yilmaz, S. 2009. Determination of Drying Characteristics of Apples in a Heat Pump and Solar Dryer. Desalination, 239(1–3): 266-275.
3. Atefi, M., Taslimi, A., Hassas, M. R. and Mazlumi, M. T. 2004. Effect of Freeze-drying Processe on the Qualitative Charactristics of Iranian Saffron. Iran J. Food Sci. Technol., 1(2): 41-49.
4. Bruce, D. M. 1985. Exposed-Layer Barley Drying, Three Models Fitted to New Data up to 150°C. J. Agric. Eng. Res., 32: 337-347.
5. Carmona, M., Zalacain, A., Pardo, J. E., López, E., Alvarruiz, A. and Alonso, G. L. 2005. Influence of Different Drying and Aging Conditions on Saffron Constituents. J. Agric. Food Chem., 53(10): 3974-3979.
6. Chandra, P. K. and Singh, R. P. 1995. Applied Numerical Methods for Food and Agricultural Engineers. CRC Press, Boca Raton, FL, PP. 163–167.
7. Chhinman, M. S. 1984. Evaluation of Selected Mathematical Models for Describing Thin Layer Drying of In-shell Pecans. Trans. ASAE, 27: 610-615.
8. Chin, S. K., Law, C. L., Supramaniam, C. V. and Cheng, P. G. 2009. Thin-Layer Drying Characteristics and Quality Evaluation of Air-dried Ganoderma Tsugae Murrill. Drying Technol., 27(9): 975-984.
9. Chua, K., Chou, S., Ho, J. and Hawlader, M. 2002. Heat Pump Drying: Recent Developments and Future Trends. Drying Technol., 20(8): 1579-1610.
10. Chua, K., Mujumdar, A., Chou, S., Hawlader, M. and Ho, J. 2000. Convective Drying of Banana, Guava and Potato Pieces: Effect of Cyclical Variations of Air Temperature on Convective Drying Kinetics and Colour Change. Drying Technol., 18(5): 907-936.
11. Das, I., Das, S. and Saha, T. 2010. Saffron Suppresses Oxidative Stress in Dmba-induced Skin Carcinoma: A Histopathological Study. Acta Histochem., 112(4): 317-327.
12. Dissa, A. O., Bathiebo, D. J., Desmorieux, H., Coulibaly, O. and Koulidiati, J. 2011. Experimental Characterisation and Modelling of Thin Layer Direct Solar Drying of Amelie and Brooks Mangoes. Energy, 36(5): 2517-2527.
13. Diamante, L. M. and Munro, P. A. 1993. Mathematical Modelling of the Thin Layer Solar Drying of Sweet Potato Slices. Solar Energy, 51(4): 271-276.
14. Erbay, Z. and Icier, F. 2009. Optimization of Drying of Olive Leaves in a Pilot-Scale Heat Pump Dryer. Drying Technol., 27(3): 416-427.
15. Evin, D. 2012. Thin Layer Drying Kinetics of Gundelia Tournefortii L. Food Bioproduct Process., 90(2): 323-332.
16. Fadhel, A., Kooli, S., Farhat, A. and Bellghith, A. 2005. Study of the Solar Drying of Grapes by Three Different Processes. Desalination, 185(1-3): 535-541.
17. Gaur, M. K. and Tiwari, G. N. 2010. Optimization of Number of Collectors for Integrated Pv/T Hybrid Active Solar Still. Appl. Energy, 87(5): 1763-1772.
18. Ghazanfari, A., Emami, S., Tabil, L. and Panigrahi, S. 2006. Thin-layer Drying of Flax Fiber: Ii. Modeling Drying Process Using Semi-Theoretical and Empirical Models. Drying Technol., 24(12): 1637-1642.
19. Ghodake, H., Goswami, T. and Chakraverty, A. 2006. Mathematical Modeling of Withering Characteristics of Tea Leaves. Drying Technol., 24(2): 159-164.
20. Gorjian, S., Hashjin, T. T., Khoshtaghaza, M. H. and Nikbakht, A.M. 2011. Drying Kinetics and Quality of Barberry in a Thin Layer. J. Agric. Sci. Technol., 13: 303-314.
21. Goyal, R. K., Kingsly, A. R. P., Manikantan, M. R. andIlyas, S. M. 2007. Mathematical Modelling of Thin Layer Drying Kinetics of Plum in a Tunnel Dryer. J. Food Eng., 79: 176-180.
22. HacIhafIzoglu, O., Cihan, A. and Kahveci, K. 2008. Mathematical Modelling of Drying of Thin Layer Rough Rice. Food Bioproduct Process., 86(4): 268-275.
23. Hariri, A. T., Moallem, S. A., Mahmoudi, M. and Hosseinzadeh, H. 2011. The Effect of Crocin and Safranal, Constituents of Saffron, against Subacute Effect of Diazinon on Hematological and Genotoxicity Indices in Rats. Phytomedic., 18(6): 499-504.
24. Hayaloglu, A. A., Karabulut, I., Alpaslan, M. and Kelbaliyev, G. 2007. Mathematical Modeling of Drying Characteristics of Strained Yoghurt in a Convective Type Tray-dryer. J. Food Eng., 78(1): 109-117.
25. Henderson, S. M. 1974. Progress in Developing the Thin-Layer Drying Equation. Trans ASAE, 17: 1167-1172.
26. Holman, J. 1994. Experimental Methods for Engineers. 2nd Edition, Mcgraw-Hill. New York, PP. 41-49.
27. Janjai, S., Precoppe, M., Lamlert, N., Mahayothee, B., Bala, B. K., Nagle, M. and Müller, J. 2011. Thin-layer Drying of Litchi (Litchi chinensis Sonn.). Food Bioproduct Process., 89(3): 194-201.
28. Kalogirou, S. A. 2001. Use of Trnsys for Modelling and Simulation of a Hybrid Pv-Thermal Solar System for Cyprus. Renew Energy, 23(2): 247-260.
29. Kanakis, C. D., Tarantilis, P. A., Pappas, C., Bariyanga, J., Tajmir-Riahi, H. A. and Polissiou, M. G. 2009. An Overview of Structural Features of DNA and Rna Complexes with Saffron Compounds: Models and Antioxidant Activity. J. Photochem. Photobiol. B: Biol., 95(3): 204-212.
30. Karathanos, V. T. 1999. Determination of Water Content of Dried Fruits by Drying Kinetics. J. Food Eng., 39(4): 337-344.
31. Kavak Akpinar, E., Bicer, Y. and Cetinkaya, F. 2006. Modelling of Thin Layer Drying of Parsley Leaves in a Convective Dryer and under Open Sun. J. Food Eng., 75: 308-315.
32. Kumar, S. and Tiwari, G. N. 2009. Estimation of Internal Heat Transfer Coefficients of a Hybrid (Pv/T) Active Solar Still. Solar Energy, 83(9): 1656-1667.
33. Lee, J. H., Kim, H. J. and Rhim, J. W. 2012. Vacuum Drying Characteristics of Salicornia Herbacea L . J. Agr. Sci. Tech., 14: 587-598.
34. Liu, X., Qiu, Z., Wang, L., Cheng, Y., Qu, H. and Chen, Y. 2009. Mathematical Modeling for Thin Layer Vacuum Belt Drying of Panax Notoginseng Extract. Energy conv. Manag., 50(4): 928-932.
35. Midilli, A., Kucuk, H. and Yapar, Z. 2002. A New Model for Single-layer Drying. Drying Technol., 20(7): 1503-1513.
36. Momenzadeh, L., Zomorodian, A. and Mowla, D. 2012. Applying Artificial Neural Network for Drying Time Prediction of Green Pea in a Microwave Assisted Fluidized Bed Dryer. J. Agr. Sci. Tech., 14: 513-522.
37. Mortezapour, H., Ghobadian, B., Khoshtaghaza, M. H. and Minaei, S. 2012a. Performance Analysis of a Two-way Hybrid Pv/Thermal Solar Collector. J. Agr. Sci. Tech., 14: 767-780.
38. Mortezapour, H., Ghobadian, B., Minaei, S. and Khoshtaghaza, M. H. 2012b. Saffron Drying with a Heat Pump–Assisted Hybrid Photovoltaic–thermal Solar Dryer. Drying Technol., 30(6): 560-566.
39. Mousavi, M. and Javan, S. 2009. Modeling and Simulation of Apple Drying , Using Artificial Neural Network and Neuro-Taguchi’s Method. J. Agr. Sci. Tech., 11: 559-571.
40. Namsanguan, Y., Tia, W., Devahastin, S. and Soponronnarit, S. 2004. Drying Kinetics and Quality of Shrimp Undergoing Different Two-stage Drying Processes. Drying Technol., 22(4): 759-778.
41. Pal, U., Khan, M. and Mohanty, S. 2008. Heat Pump Drying of Green Sweet Pepper. Drying Technol., 26(12): 1584-1590.
42. Pangavhane, D. R., Sawhney, R. L. and Sarsavadia, P. N. 2002. Design, Development and Performance Testing of a New Natural Convection Solar Dryer. Energy, 27(6): 579-590.
43. Prasertsan, S. and Saen-Saby, P. 1998. Heat Pump Drying of Agricultural Materials. Drying Technol., 16(1/2): 235-250.
44. Punlek, C., Pairintra, R., Chindaraksa, S. and Maneewan, S. 2009. Simulation Design and Evaluation of Hybrid Pv/T Assisted Desiccant Integrated Ha-Ir Drying System(Hpird). Food Bioproduct Process., 87(2): 77-86.
45. Rafiee, S., Keyhani, A., Sharifi, M., Jafari, A., Mobli, H. and Tabatabaeefar, A. 2009. Thin Layer Drying Properties of Soybean (Viliamz Cultivar). J. Agr. Sci. Tech., 11: 289-300.
46. Rania, B. L., Agarwal, S. G. and Gaur, G. S. 1996. Changes in Pigments and Volatiles of Saffron (Crocus sativus L.) During Processing and Storage. J. Sci. Food Agric., 71: 27-32.
47. Sacilik, K., Keskin, R. and Elicin, A. K. 2006. Mathematical Modelling of Solar Tunnel Drying of Thin Layer Organic Tomato. J. Food Eng., 73(3): 231-238.
48. Sarhaddi, F., Farahat, S., Ajam, H., Behzadmehr, A. and Mahdavi Adeli, M. 2010. An Improved Thermal and Electrical Model for a Solar Photovoltaic Thermal (Pv/T) Air Collector. Appl. Energy., 87: 2328-2339.
49. Shamsa, A., Hosseinzadeh, H., Molaei, M., Shakeri, M. T.and Rajabi, O. 2009. Evaluation of Crocus sativus L. (Saffron) on Male Erectile Dysfunction: A Pilot Study. Phytomedicine, 16(8): 690-693.
50. Stone, R. J. 1993. Improved Statistical Procedure for the Evaluation of Solar Radiation Estimation Models. Solar Energy, 51(4): 289-291.
51. Tahmasebi, M., Hashjin, T. T., Khoshtaghaza, M. H.and Nikbakht, A. M. 2011. Evaluation of Thin-Layer Drying Models for Simulation of Drying Kinetics of Quercus (Quercus persica and Quercus libani). J. Agr. Sci. Tech., 13: 155-163.
52. Taslimi, A., Mazlumi, M. T. and Jamshidi, E. 2006. The Comparison of the Effects of the Solar, Vacuum and Traditional Way of Drying on the Qualitative Chrematistics of the Iranian Saffron. Iran J. Food Sci. Technol., 3(3): 9-18.
53. Tiris, C., Tiris, M. and Dincer, I. 1995. Investigation of the Thermal Efficiencies of a Solar Dryer. Energy Conv. Manag., 36(3): 205-212.
54. Tiwari, A. and Sodha, M. S. 2006. Performance Evaluation of Solar Pv/T System: An Experimental Validation. Solar Energy, 80(7): 751-759.
55. Togrul, I. T. and Pehlivan, D. 2002. Mathematical Modelling of Solar Drying of Apricots in Thin Layers. J. Food Eng., 55(3): 209-216.
56. Vega-Gálvez, A., Miranda, M., Díaz, L. P., Lopez, L., Rodriguez, K. and Di Scala, K. 2010. Effective Moisture Diffusivity Determination and Mathematical Modelling of the Drying Curves of the Olive-Waste Cake. Bioresour. Technol., 101(19): 7265-7270.
57. Wang, Z., Sun, J., Chen, F., Liao, X. and Hu, X. 2007. Mathematical Modelling on Thin Layer Microwave Drying of Apple Pomace with and without Hot Air Pre-drying. J. Food Eng., 80(2): 536-544.
58. Verma, L. R., Bucklin, R. A., Endan, J. B. and Wratten, F. T. 1985. Effects of Drying Air Parameters on Rice Drying Models. Trans. ASAE, 28: 296-301.
59. Wang, C. and Singh, R. 1978. A Single Layer Drying Equation for Rough Rice. ASAE Technical Paper, No. 78-3001.
60. Zomorodian, A. and Moradi, M. 2010. Mathematical Modeling of Forced Convection Thin Layer Solar Drying for Cuminum cyminum. J. Agr. Sci. Tech., 12: 401-408.
61. Zomorodian, A. A. and Dadashzadeh, M. 2009. Indirect and Mixed Mode Solar Drying Mathematical Models for Sultana Grape. J. Agr. Sci. Tech., 11: 391-400.
Journal of Agricultural Science and Technology
Volume 16, Issue 1
January and February 2014
Pages 33-45